Aston, PA Asphalt Paving & Sealcoating
Driveways, parking lots, sealcoating and asphalt repair — installed and maintained by a local, third-generation crew across Delaware, southeastern Pennsylvania and South Jersey.
Local Paving
Paving in Aston, PA
Aston is an established Delaware County township built around Route 452, Pennell Road, and Concord Road, and most of the residential streets here were paved years ago rather than recently — meaning resurfacing and repair make up more of our work than first-time installs. Mature trees along older streets mean root heave is a real factor in why a driveway that once looked fine starts cracking or settling unevenly.
The township's commercial corridors, along with parking areas near Neumann University, see steady daily traffic that calls for a sturdier mix and more durable striping than a quiet residential block needs. Toward Chester and Brookhaven, Aston's paving work is a fairly even split between resurfacing older residential streets and maintaining that corridor-level commercial durability.
Our Process
How we pave an Aston driveway or lot
Every job follows the same disciplined sequence — the base and drainage work you can’t see is what keeps the surface you can see from cracking, sinking, or holding water a few winters later.
- 1
Site inspection
We walk the site — an older residential driveway off Pennell Road, or campus-adjacent parking near Neumann University — and evaluate the existing surface, drainage, and how daily traffic will load the new pavement. On Aston’s older streets we look closely at whether mature-tree roots have pushed up or cracked the existing slab.
- 2
Removal & prep
Aston’s older asphalt — driveways paved years ago rather than recently — is fully removed along with any unstable base material, and any root-heaved sections are addressed so the new surface starts on solid, level ground.
- 3
Grading & drainage
The surface is graded to move water off the pavement and out to the street, correcting the low spots and settled areas that tend to develop on an older, established driveway over the decades.
- 4
Stone base
A compacted stone base is installed or rebuilt — especially important on Aston’s long-established streets, where decades of settling and, in places, tree-root disturbance have weakened what’s underneath.
- 5
Asphalt installation
Hot-mix asphalt is laid at a depth suited to the job — a heavier commercial-grade mix for the township’s corridor lots and campus-adjacent parking, standard depth for driveways on the older residential blocks.
- 6
Rolling & compaction
Professional rollers compact the asphalt into a dense, even surface built to stand up to the steady daily traffic along corridors like Route 452 and Concord Road.
- 7
Cleanup & finishing
We clean the site and handle finishing work; striping for commercial and campus lots is scheduled once the asphalt has cured enough to hold a line.
- 8
Aftercare
Most residential jobs take one to a few days, and we schedule commercial work around business hours. Keep vehicles off for at least 48 hours and follow the aftercare we provide.
Services
Our services in Aston
Residential driveways
Hot-mix asphalt driveways, resurfacing, and repairs for Aston homeowners — built for our region’s freeze-thaw cycles and graded to drain.
Commercial & parking lots
Parking-lot construction, line striping, and sealcoating for Aston businesses, HOAs, and property managers — built for traffic and easy to maintain.
Repair, resurface, or replace
The right fix for your driveway
Most of Aston’s residential streets were paved years ago, so more of our work here is resurfacing and repair than first-time installs — and the right fix comes down to the base underneath. If it’s still sound, you have affordable options; if it’s failing, resurfacing over it only buys a little time before cracks reflect back through. Here’s how we tell the difference on an Aston property, and what each path means for cost and how long it lasts.
Sealcoat & crack fill
For a sound surface with minor wear. Filling small cracks early keeps water and winter road salt out of the base before the freeze-thaw cycle can widen them — worthwhile on any Aston driveway not yet showing deeper trouble.
Resurface
The call we make most often in Aston: when the surface is worn but the base is still solid — typical of the township’s older residential blocks — a new asphalt layer over a prepared surface restores it for far less than a full rebuild.
Replace
Alligator cracking, sinking, standing water, or a slab lifted and split by tree roots usually mean the base itself has failed. We remove and rebuild the base and drainage — and deal with the root issue — so the new surface actually lasts.
Maintenance
Keeping Aston asphalt in shape year-round
Spring
Inspect for cracks, potholes, and standing water after a winter of plow scraping and road salt, and check for any new heaving where a mature tree’s roots run under or alongside the driveway.
Summer
Warm, dry weather is ideal for crack filling and sealcoating on older residential driveways and corridor lots — repairing early keeps water out of the base before fall traffic picks back up.
Fall
Clear leaves and debris from driveway aprons and parking-lot drains — a real task on Aston’s tree-lined streets — and repair open cracks before the freeze-and-thaw cycle and the first plow pass work them wider.
Winter
Plows and road salt are hard on asphalt edges and curb lines. Use plastic snow shovels, not metal blades, and keep harsh deicers off the surface where you can, especially on older pavement that’s already been through many winters.
Why H&H
Local, licensed, and built on base work
H&H is owned by Henry, a third-generation paving contractor with over a decade in the trade, serving Aston and the rest of Delaware County — including Brookhaven, Chester, Concordville, and Media. Licensed and fully insured, our crew focuses on the base prep, grading, drainage, and compaction that decide whether a driveway or corridor lot holds up to the daily traffic along Route 452 and Concord Road and winter plowing — and we give straight answers on whether repair, resurfacing, or replacement is the best value for your property.
FAQ
Aston asphalt paving questions
My driveway is cracking near a big tree — is that the root cause?
Often, yes. On Aston’s older, tree-lined streets, roots from mature trees push up and crack a driveway that once sat flat — and simply paving over the lifted section lets it come back. We assess how far the roots have run, level and rebuild the affected base, and in some cases adjust the layout so the new surface has a real chance to stay put.
Do I need a permit to repave my driveway in Aston Township?
It depends on the work and where it sits. Aston Township regulates grading and work in the public right-of-way, and any new curb cut typically needs review; simple resurfacing inside your existing driveway usually doesn’t. Rules vary, so we confirm what applies and pull any permits before we start.
My driveway meets Route 452 or another state road — does that matter?
It can. Where a driveway or lot connects to a state-maintained road like Route 452 (Pennell Road) rather than a township street, PennDOT issues the entrance permit and reviews sight distance and drainage. We handle that step; a township-road connection is reviewed by the township instead.
When is the best time of year to pave in Aston?
Late spring through early fall. Warm, dry conditions let the asphalt compact and cure properly, which matters in our Mid-Atlantic climate where winter brings plow scraping and road salt.
My driveway is decades old — resurface or full replacement?
It depends on the base. Many of Aston’s older driveways still have a sound base under worn asphalt, in which case resurfacing costs far less than a full rebuild. If we see alligator cracking, sinking, standing water, or root-driven heaving, the base has likely failed and needs to be rebuilt.
How long does asphalt last with Aston’s winters?
With proper base preparation and regular sealcoating, an asphalt driveway or lot commonly lasts 15 to 20+ years, even with the freeze-thaw stress and snowplow scraping a full Mid-Atlantic winter puts on an established driveway.
Service Area
Where we pave near Aston
Nearby
Nearby service areas
What our customers say
Tell us about the job
Call Henry directly, or send the address and what you need. You’ll get a free consultation, a free pavement analysis and a written estimate at no cost.
302.480.7660 henry@hhasphaltpaving.com